Influence of large diameter deep buried pipe jacking construction on surface settlement
-
摘要:
顶管施工因非开挖或少开挖而在城市建设中应用广泛, 但顶管施工引起的地表沉降不容忽视。依托佛山市某电力隧道顶管工程, 通过现场实测、数值模拟及Peck经验公式的方法研究了顶管施工引起的地表沉降规律, 探讨了管-土摩擦、注浆压力及支护压力对地表沉降的影响。结果表明: 顶管施工引起的横向地表沉降在距轴线约4倍管径范围内变化较大, 管-土摩擦的改变对横向地表距轴线约3倍管径范围内的地表沉降影响较大, 对纵向地表距开挖面约1倍管径范围内的地表沉降影响较小; 注浆压力的增大能够抑制地表沉降; 支护压力的改变对横向地表距轴线约2倍管径范围内的地表沉降影响较大。研究结果可为控制顶管施工引起地表沉降措施的制定提供参考; 同时, 实测值、模拟值及Peck经验公式所得到的地表沉降变化趋势和大小相近, 验证了数值模拟及Peck经验公式在实际工程中预测地表沉降的可行性。
Abstract:Pipe jacking construction is widely used in urban construction due to non-excavation or less excavation, but the surface settlement caused by pipe jacking construction cannot be ignored. Relying on a pipe jacking project of a power tunnel in Foshan City, the law of surface settlement caused by pipe jacking construction was studied through field measurements, numerical simulations and Peck empirical formulas, and the effects of pipe-soil friction, grouting pressure and supporting pressure on the ground settlement were discussed. The results show that the lateral surface settlement caused by pipe jacking construction changes greatly within the range of approximately four pipe diameters from the axis, and the change in pipe-soil friction has a greater impact on the surface settlement within the range of approximately three pipe diameters from the axis. It has little effect on the surface settlement within the range of approximately one pipe diameter from the longitudinal ground surface to the excavation surface; the increase in grouting pressure can restrain the settlement of the surface. The surface settlement has a greater impact, and the research results can provide references for measures to control surface settlement caused by pipe jacking construction. At the same time, the measured value, simulated value and Peck's empirical formula have similar ground settlement trends and magnitudes, verifying the feasibility of numerical simulation and Peck's empirical formula in predicting surface settlement in actual projects.
-
表 1 土体、顶管机及管节材料参数
Table 1. Material parameters of the soil, pipe jacking machine and pipe joints
部件 土层名称 密度/(kg·m-3) 弹性模量/MPa 泊松比υ 内摩擦角/(°) 黏聚力/kPa 土体 ①素填土 1 900 10.0 0.35 12.0 6.0 ④-2粉砂 1 800 22.0 0.32 24.0 2.0 ②淤泥质土 1 720 9.6 0.42 6.2 9.7 ⑥圆砾 2 100 52.0 0.25 40.0 0 ⑦-1泥质粉砂岩 2 250 146.0 0.25 30.0 40.0 ⑦-2泥质粉砂岩 2 450 150.0 0.25 45.0 68.0 顶管机及管节 顶管机 7 850 16 000.0 0.30 — — 管节 2 500 3 500.0 0.20 — — -
[1] 马保松. 非开挖工程学[M]. 北京: 人民交通出版社, 2008.Ma B S. Trenchless engineering[M]. Beijing: People's Communications Press, 2008(in Chinese). [2] 张海丰, 周维, 张鹏, 等. 管土相互作用土箱模型实验设计[J]. 地质科技情报, 2016, 35(4): 219-222. https://www.cnki.com.cn/Article/CJFDTOTAL-DZKQ201604035.htmZhang H F, Zhou W, Zhang P, et al. Experimental design of soil box model for pipe-soil interaction[J]. Geological Science and Technology Information, 2016, 35(4): 219-222(in Chinese with English abstract). https://www.cnki.com.cn/Article/CJFDTOTAL-DZKQ201604035.htm [3] Peck R B. Deep excavations and tunneling in soft ground[C]//Anon. Proc. of 7th ICSMFE, Mexico. [S. l.]: [s. n.], 1969. [4] Attewell P B, Farmer I W. Ground settlement above shield driven tunnels in clay[J]. International Journal of Rock Mechanics & Mining Sciences & Geomechanics Abstracts, 1975, 12(4): 61. [5] Mair R J, Taylor R N, Bracegirdle A. Subsurface settlement profiles above tunnels in clay[J]. Géotechnique, 1995, 45(2): 361-362. doi: 10.1680/geot.1995.45.2.361 [6] Loganathan N. Analytical prediction for tunneling-induced ground movements in clays[J]. Journal of Geotechnical & Geoenvironmental Engineering, 1998, 124(9): 846-856. [7] 魏纲, 吴华君, 陈春来. 顶管施工中土体损失引起的沉降预测[J]. 岩土力学, 2007, 28(2): 359-359. doi: 10.3969/j.issn.1000-7598.2007.02.030Wei G, Wu H J, Chen C L. Prediction of settlement induced by ground loss during pipe jacking construction[J]. Rock and Soil Mechanics, 2007, 28(2): 359-359(in Chinese with English abstract). doi: 10.3969/j.issn.1000-7598.2007.02.030 [8] Sagaseta C. Analysis of undraind soil deformation due to ground loss[J]. Geotechnique, 1987, 37(3): 301-320. doi: 10.1680/geot.1987.37.3.301 [9] Verruijt A, Booker J R. Surface settlements due to deformation of a tunnel in an elastic half plane[J]. Géotechnique, 1998, 46(5): 753-756. [10] 夏元友, 陈春舒, 王智德, 等. 浅埋隧道开挖引起的土体水平位移分析[J]. 岩土力学, 2015, 36(2): 354-360. https://www.cnki.com.cn/Article/CJFDTOTAL-YTLX201502009.htmXia Y Y, Chen C S, Wang Z D, et al. Analysis of horizontal displacement of soil induced by shallow tunnel excavation[J]. Rock and Soil Mechanics, 2015, 36(2): 354-360(in Chinese with English abstract). https://www.cnki.com.cn/Article/CJFDTOTAL-YTLX201502009.htm [11] 杨金虎, 陈卫兵, 张莉, 等. 双层顶管隧道施工引起的土体竖向变形规律研究[J]. 科学技术与工程, 2014, 14(29): 274-279. doi: 10.3969/j.issn.1671-1815.2014.29.053Yang J H, Chen W B, Zhang L, et al. Research on varying regularity of soil vertical deformation caused by the construction of two-layer jacking-pipe[J]. Science Technology and Engineering, 2014, 14(29): 274-279(in Chinese with English abstract). doi: 10.3969/j.issn.1671-1815.2014.29.053 [12] 段景川, 吴勇, 严佳佳, 等. 浅埋大断面顶管施工引起地基变形规律分析[J]. 建筑结构, 2016(增刊2): 510-515. https://www.cnki.com.cn/Article/CJFDTOTAL-JCJG2016S2109.htmDuan J C, Wu Y, Yan J J, et al. Analysis of measured result of surface deformation induced by pipe jacking construction[J]. Building Structure, 2016(S2): 510-515(in Chinese with English abstract). https://www.cnki.com.cn/Article/CJFDTOTAL-JCJG2016S2109.htm [13] 马清杰, 李小杰, 谢延锁, 等. 浅埋顶管隧道下穿施工对路面变形影响的数值分析[J]. 现代隧道技术, 2018, 55(增刊2): 411-418. https://www.cnki.com.cn/Article/CJFDTOTAL-XDSD2018S2055.htmMa Q J, Li X J, Xie Y S, et al. Numerical analysis of the influence on pavement settlement caused by shallow buried pipe jacking tunnel passing beneath the main road[J]. Modern Tunnelling Technology, 2018, 55(S2): 411-418(in Chinese with English abstract). https://www.cnki.com.cn/Article/CJFDTOTAL-XDSD2018S2055.htm [14] 张艳林, 曾天成, 甘甜, 等. 真实复杂地层大直径钢顶管三维数值模拟研究[J]. 科学技术与工程, 2020, 20(33): 13791-13798. doi: 10.3969/j.issn.1671-1815.2020.33.040Zhang Y L, Zeng T C, Gan T, et al. Three-dimensional numerical simulation of large-diameter steel pipe jacking in real and complex strata[J]. Science Technology and Engineering, 2020, 20(33): 13791-13798(in Chinese with English abstract). doi: 10.3969/j.issn.1671-1815.2020.33.040 [15] 王道伟, 王福芝, 黎轩, 等. 水平平行顶管相互影响试验研究[J]. 地质科技情报, 2016, 35(2): 71-74. https://www.cnki.com.cn/Article/CJFDTOTAL-DZKQ201602017.htmWang D W, Wang F Z, Li X, et al. Experimental study on the mutual influence of horizontal parallel pipe jacking[J]. Geological Science and Technology Information, 2016, 35(2): 71-74(in Chinese with English abstract). https://www.cnki.com.cn/Article/CJFDTOTAL-DZKQ201602017.htm [16] 郑跃, 丁文其, 陈立生. 受顶管施工影响的土体扰动分析与实测研究[J]. 地下空间与工程学报, 2010, 6(5): 1015-1020. https://www.cnki.com.cn/Article/CJFDTOTAL-BASE201005029.htmZheng Y, Ding W Q, Chen L S. Study of measured data and soil disturbance influenced by pipe jacking construction[J]. Chinese Journal of Underground Space and Engineering, 2010, 6(5): 1015-1020(in Chinese with English abstract). https://www.cnki.com.cn/Article/CJFDTOTAL-BASE201005029.htm [17] 周浩, 周千淼, 谈力昕, 等. 考虑注浆作用的矩形顶管竖向土压力计算模型[J]. 地质科技通报, 2021, 40(2): 125-130. doi: 10.19509/j.cnki.dzkq.2021.0201Zhao H, Zhou Q M, Tab L X, et al. Calculation model of vertical earth pressure of rectangular pipe jacking considering grouting[J]. Bulletin of Geological Science and Technology, 2021, 40(2): 125-130 (in Chinese with English abstract). doi: 10.19509/j.cnki.dzkq.2021.0201 [18] 黄建华, 鲍锋, 王蕴晨, 等. 并行差异断面顶管施工对地表变形的影响[J]. 地质科技通报, 2021, 40(6): 185-192. doi: 10.19509/j.cnki.dzkq.2021.0618Huang J H, Bao F, Wang Y C, et al. Effect of parallel differential section pipe jacking construction on surface deformation[J]. Bulletin of Geological Science and Technology, 2021, 40(6): 185-192 (in Chinese with English abstract). doi: 10.19509/j.cnki.dzkq.2021.0618 [19] 李方楠, 沈水龙, 罗春泳. 考虑注浆压力的顶管施工引起土体变形计算方法[J]. 岩土力学, 2012, 33(1): 204-208. https://www.cnki.com.cn/Article/CJFDTOTAL-YTLX201201032.htmLi F N, Shen S L, Luo C Y. Calculation method of soil deformation caused by pipe jacking construction considering grouting pressure[J]. Rock and Soil Mechanics, 2012, 33(1): 204-208(in Chinese with English abstract). https://www.cnki.com.cn/Article/CJFDTOTAL-YTLX201201032.htm [20] 城市轨道交通工程监测技术规范: GB50911-2013[S]. 北京: 中国建筑工业出版社, 2014.Technical code for urban rail transit engineering monitoring: GB50911-2013[S]. Beijing: China Construction Industry Press, 2014(in Chinese). -