CSCD来源期刊

北大中文核心期刊

中国科技核心期刊

地学领域高质量科技期刊分级T2区（2023）

世界期刊影响力指数报告Q1区（2023）

Volume 42 Issue 2
Mar.  2023
Turn off MathJax
Article Contents
Article Navigation >  Bulletin of Geological Science and Technology  > 2023  >  42(2): 356-364
Chen Shuai, Shi Xiangchao, Gao Leiyu, Tang Yang, Li Qingling. Experiment research of the influence of different cooling times on the drillability of high-temperature granite[J]. Bulletin of Geological Science and Technology, 2023, 42(2): 356-364. doi: 10.19509/j.cnki.dzkq.2022.0102
Citation: Chen Shuai, Shi Xiangchao, Gao Leiyu, Tang Yang, Li Qingling. Experiment research of the influence of different cooling times on the drillability of high-temperature granite[J]. Bulletin of Geological Science and Technology, 2023, 42(2): 356-364. doi: 10.19509/j.cnki.dzkq.2022.0102
shu

Experiment research of the influence of different cooling times on the drillability of high-temperature granite

doi: 10.19509/j.cnki.dzkq.2022.0102

  • State Key Laboratory of Oil and Gas Reservoir Geology and Exploitation, Southwest Petroleum University, Chengdu 610500, China

  • Received Date: 19 Aug 2021
    Abstract

  • To study the drillability and microscopic damage changes of granite after high temperature exposure and to study the influence of different cooling times on drillability after high temperature exposure, granite for high-temperature heat treatment was cooled by different times (2 h, 4 h, 24 h, and 48 h). Through the drillability experiment and the cast thin identification of the processed rock samples, the influence law and mechanism of high temperature on the drillability of granite were obtained, and the influence of different cooling times on the granite drillability was also investigated. The research results show that granite always maintains a high drillability index under the constraints of heat treatment not exceeding 500℃ and natural cooling for 2 h. After cooling 4 h, 24 h, and 48 h, the impact of high temperature on drillability shows three stages (First degradation stage, strengthening stage, second degradation stage). The location and number of microcracks affect the difficulty of rock resistance to crushing. After 400℃ heat treatment, the internal microcracks of the granite begin to increase significantly. When the microcracks generate a large number of microcracks inside the quartz particles, the drillability of the granite is significantly reduced. After heat treatment at 100℃, cooling for no more than 4 h at the same time will significantly affect the drillability of granite. After heat treatment at 200-400℃, the drillability index of granite will increase significantly as the cooling time (4-48 h) continues to increase. The damage caused by 500℃ to granite is irreversible, and 600℃ has completely degraded the granite. Understanding the influence of high temperature and cooling time on the drillability of granite can provide basic theoretical support for the efficient exploitation of hot dry rock resources.

     

    • FullText(HTML)
  • loading
    • References(38)
  • [1]
    刘德民, 张昌生, 孙明行, 等. 干热岩勘查评价指标与形成条件[J]. 地质科技通报, 2021, 40(3): 1-11 doi: 10.19509/j.cnki.dzkq.2021.0316

    Liu D M, Zhang C S, Sun M X, et al. Evaluation indexes and formation conditions of hot dry rock exploration[J]. Bulletin of Geological Science and Technology, 2021, 40(3): 1-11(in Chinese with English abstract). doi: 10.19509/j.cnki.dzkq.2021.0316
    [2]
    王贵玲, 张薇, 梁继运, 等. 中国地热资源潜力评价[J]. 地球学报, 2017, 38(4): 449-450. https://www.cnki.com.cn/Article/CJFDTOTAL-DQXB201704002.htm

    Wang G L, Zhang W, Liang J Y, et al. Evaluation of geothermal resources potential in China[J]. Acta Geoscientica Sinica, 2017, 38(4): 449-450(in Chinese with English abstract). https://www.cnki.com.cn/Article/CJFDTOTAL-DQXB201704002.htm
    [3]
    朱喜, 张庆莲, 刘彦广. 基于热储法的鲁西平原地热资源评价[J]. 地质科技情报, 2016, 35(4): 172-177. https://www.cnki.com.cn/Article/CJFDTOTAL-DZKQ201604027.htm

    Zhu X, Zhang Q L, Liu Y G. Evaluation of the geothermal resources in the plain of West Shandong Province[J]. Geological Science and Technology Information, 2016, 35(4): 172-177(in Chinese with English abstract). https://www.cnki.com.cn/Article/CJFDTOTAL-DZKQ201604027.htm
    [4]
    窦斌, 高辉, 周刚, 等. 我国发展增强型地热开采技术所面临的机遇与挑战[J]. 地质科技情报, 2014, 33(5): 208-210. https://www.cnki.com.cn/Article/CJFDTOTAL-DZKQ201405032.htm

    Dou B, Gao H, Zhou G, et al. Opportunities and challenges of developing enhance geothermal system technology in China[J]. Geological Science and Technology Information, 2014, 33(5): 208-210(in Chinese with English abstract). https://www.cnki.com.cn/Article/CJFDTOTAL-DZKQ201405032.htm
    [5]
    王贵玲, 张发旺, 刘志明. 国内外地热能开发利用现状及前景分析[J]. 地球学报, 2000, 21(2): 134-139. doi: 10.3321/j.issn:1006-3021.2000.02.004

    Wang G L, Zhang F W, Liu Z M. An analysis of present situation and prospects of geothermal energy development and utilization in the world[J]. Acta Geoscientica Sinica, 2000, 21(2): 134-139(in Chinese with English abstract). doi: 10.3321/j.issn:1006-3021.2000.02.004
    [6]
    赵静, 王旭升, 万力. 深层地热资源评价中的回收率问题[J]. 地质科技情报, 2008, 27(6): 89-92. doi: 10.3969/j.issn.1000-7849.2008.06.017

    Zhao J, Wang X S, Wang L. The recovery rate in assessment of deep geothermal resources[J]. Geological Science and Technology Information, 2008, 27(6): 89-92(in Chinese with English abstract). doi: 10.3969/j.issn.1000-7849.2008.06.017
    [7]
    王贵玲. 我国地热资源勘查评价战略研究[J]. 地热能, 2010(6): 15-20. https://cpfd.cnki.com.cn/Article/CPFDTOTAL-IGNH201010001010.htm

    Wang G L. Study on exploration and evaluation strategy of geothermal resources in China[J]. Geothermal Energy, 2010(6): 15-20(in Chinese with English abstract). https://cpfd.cnki.com.cn/Article/CPFDTOTAL-IGNH201010001010.htm
    [8]
    王贵玲, 刘彦广, 朱喜, 等. 中国地热资源现状及发展趋势[J]. 地学前缘, 2020, 27(1): 1-9. https://www.cnki.com.cn/Article/CJFDTOTAL-DXQY202001002.htm

    Wang G L, Liu Y G, Zhu X, et al. The status and development trend of geothermal resources in China[J]. Earth Science Frontiers, 2020, 27(1): 1-9(in Chinese with English abstract). https://www.cnki.com.cn/Article/CJFDTOTAL-DXQY202001002.htm
    [9]
    方新宇, 许金余, 刘石, 等. 高温后花岗岩的劈裂试验及热损伤特性研究[J]. 岩石力学与工程学报, 2016, 35(增刊1): 2687-2694. https://www.cnki.com.cn/Article/CJFDTOTAL-YSLX2016S1012.htm

    Fang X Y, Xu J Y, Liu S, et al. Research on splitting-tensile tests and thermal damage of granite under post-high temperature[J]. Chinese Journal of Rock Mechanics and Engineering, 2016, 35(S1): 2687-2694(in Chinese with English abstract). https://www.cnki.com.cn/Article/CJFDTOTAL-YSLX2016S1012.htm
    [10]
    Qin Y, Jing H W, Liu R C, et al. Pore characteristics and nonlinear flow behaviors of granite exposed to high temperature[J]. Bulletin of Engineering Geology and the Environment, 2020, 79(3): 1239-1257. doi: 10.1007/s10064-019-01628-6
    [11]
    Qin Y, Tian H, Xu N X, et al. Physical and mechanical properties of granite after high-temperature treatment[J]. Rock Mechanics and Rock Engineering, 2020, 53(1): 305-322. doi: 10.1007/s00603-019-01919-0
    [12]
    阴伟涛, 赵阳升, 冯子军. 高温三轴应力下粗、细粒花岗岩力学特性研究[J]. 太原理工大学学报, 2020, 51(5): 627-633. https://www.cnki.com.cn/Article/CJFDTOTAL-TYGY202005002.htm

    Yin W T, Zhan Y S, Feng Z J. Study on the mechanical properties of coarse-grained and fine-grained granite under high temperature triaxial stress[J]. Journal of Taiyuan University of Technology, 2020, 51(5): 627-633(in Chinese with English abstract). https://www.cnki.com.cn/Article/CJFDTOTAL-TYGY202005002.htm
    [13]
    苏国韶, 陈智勇, 尹宏雪, 等. 高温后花岗岩岩爆的真三轴试验研究[J]. 岩土工程学报, 2016, 38(9): 1586-1594. https://www.cnki.com.cn/Article/CJFDTOTAL-YTGC201609006.htm

    Su G S, Chen Z Y, Yin H X, et al. True triaxial tests on rockburst of granite after high temperatures[J]. Chinese Journal of Geotechnical Engineering, 2016, 38(9): 1586-1594(in Chinese with English abstract). https://www.cnki.com.cn/Article/CJFDTOTAL-YTGC201609006.htm
    [14]
    马兵, 陈虹宇. 高温后花岗岩声发射特征与损伤演化规律[J]. 矿业研究与开发, 2020, 40(1): 22-27. https://www.cnki.com.cn/Article/CJFDTOTAL-KYYK202001005.htm

    Ma B, Chen H Y. Acoustic emission characteristics and damage evolution of granite after elevated temperature[J]. Mining Research and Development, 2020, 40(1): 22-27(in Chinese with English abstract). https://www.cnki.com.cn/Article/CJFDTOTAL-KYYK202001005.htm
    [15]
    周波, 汪海阁, 张富成, 等. 温度压力对岩石可钻性和破岩效率影响实验[J]. 石油钻采工艺, 2020, 42(5): 547-552. https://www.cnki.com.cn/Article/CJFDTOTAL-SYZC202005003.htm

    Zhou B, Wang H G, Zhang F C, et al. Experiments on the influences of temperature and pressure on rock drillability and rock breaking efficiency[J]. Oil Drilling & Production Technology, 2020, 42(5): 547-552(in Chinese with English abstract). https://www.cnki.com.cn/Article/CJFDTOTAL-SYZC202005003.htm
    [16]
    赵金昌, 万志军, 李义, 等. 高温高压条件下花岗岩切削破碎试验研究[J]. 岩石力学与工程学报, 2009, 28(7): 1432-1438. https://www.cnki.com.cn/Article/CJFDTOTAL-YSLX200907019.htm

    Zhao J C, Wan Z J, Li Y, et al. Research on granite cutting and breaking test under conditions of high temperature and high pressure[J]. Chinese Journal of Rock Mechanics and Engineering, 2009, 28(7): 1432-1438(in Chinese with English abstract). https://www.cnki.com.cn/Article/CJFDTOTAL-YSLX200907019.htm
    [17]
    刘石, 许金余. 高温作用对花岗岩动态压缩力学性能的影响研究[J]. 振动与冲击, 2014, 33(4): 195-198. https://www.cnki.com.cn/Article/CJFDTOTAL-ZDCJ201404035.htm

    Liu S, Xu J Y. Effect of high temperature on dynamic compressive mechanical properties of granite[J]. Journal of Vibration and Shock, 2014, 33(4): 195-198(in Chinese with English abstract). https://www.cnki.com.cn/Article/CJFDTOTAL-ZDCJ201404035.htm
    [18]
    吴阳春, 郤保平, 王磊, 等. 高温后花岗岩的物理力学特性试验研究[J]. 中南大学学报: 自然科学版, 2020, 51(1): 193-203. https://www.cnki.com.cn/Article/CJFDTOTAL-ZNGD202001022.htm

    Wu Y C, Xi B P, Wang L, et al. Experimental study on physico-mechanical properties of granite after high temperature[J]. Journal of Central South University: Science and Technology Edition, 2020, 51(1): 193-203(in Chinese with English abstract). https://www.cnki.com.cn/Article/CJFDTOTAL-ZNGD202001022.htm
    [19]
    喻勇, 徐达, 窦斌, 等. 高温花岗岩遇水冷却后可钻性试验研究[J]. 地质科技情报, 2019, 38(4): 287-292. https://www.cnki.com.cn/Article/CJFDTOTAL-DZKQ201904031.htm

    Yu Y, Xu D, Dou B, et al. Experimental study on drillability of high temperature granite after water cooling[J]. Geological Science and Technology Information, 2019, 38(4): 287-292(in Chinese with English abstract). https://www.cnki.com.cn/Article/CJFDTOTAL-DZKQ201904031.htm
    [20]
    张帆, 操旺进, 胡大伟, 等. 高温水冷后循环加卸载条件下花岗岩的渗透性[J]. 沈阳工业大学学报, 2021, 43(1): 82-90. https://www.cnki.com.cn/Article/CJFDTOTAL-SYGY202101015.htm

    Zhang F, Cao W J, Hu D W, et al. Permeability of granite under cyclic loading and unloading conditions after high temperature water cooling[J]. Journal of Shenyang University of Technology, 2021, 43(1): 82-90(in Chinese with English abstract). https://www.cnki.com.cn/Article/CJFDTOTAL-SYGY202101015.htm
    [21]
    余莉, 彭海旺, 李国伟, 等. 花岗岩高温-水冷循环作用下的试验研究[J]. 岩土力学, 2021, 42(4): 1-11. https://www.cnki.com.cn/Article/CJFDTOTAL-YTLX202104015.htm

    Yu L, Peng H W, Li G W, et al. Experimental study on granite under the action of high temperature and water cooling[J]. Rock and Soil Mechanics, 2021, 42(4): 1-11(in Chinese with English abstract). https://www.cnki.com.cn/Article/CJFDTOTAL-YTLX202104015.htm
    [22]
    张宇皓, 段志波, 张帆. 高温水冷后花岗岩微观孔径及渗透性分析[J]. 科学技术与工程, 2021, 21(1): 297-302. https://www.cnki.com.cn/Article/CJFDTOTAL-KXJS202101042.htm

    Zhang Y H, Duan Z B, Zhang F. Analysis of micro-pore structure and permeability of granite after heating and water quenching[J]. Science Technology and Engineering, 2021, 21(1): 297-302(in Chinese with English abstract). https://www.cnki.com.cn/Article/CJFDTOTAL-KXJS202101042.htm
    [23]
    杨凯, 杨志瑞, 申梓岐. 高温对花岗岩物理及力学性质的影响[J]. 南方农机, 2020, 51(21): 196-198. https://www.cnki.com.cn/Article/CJFDTOTAL-NFLJ202021090.htm

    Yang K, Yang Z R, Shen Z Q. Effects of high temperature on physical and mechanical properties of granites[J]. South Agricultural Machinery, 2020, 51(21): 196-198(in Chinese with English abstract). https://www.cnki.com.cn/Article/CJFDTOTAL-NFLJ202021090.htm
    [24]
    罗生银, 窦斌, 田红. 自然冷却后与实时高温下花岗岩物理力学性质对比试验研究[J]. 地学前缘, 2020, 27(1): 178-184. https://www.cnki.com.cn/Article/CJFDTOTAL-DXQY202001022.htm

    Luo S Y, Dou B, Tian H. Comparative experimental study on physical and mechanical properties of granite after natural cooling and under real-time high temperature[J]. Earth Science Frontiers, 2020, 27(1): 178-184(in Chinese with English abstract). https://www.cnki.com.cn/Article/CJFDTOTAL-DXQY202001022.htm
    [25]
    梅冬, 曾石友, 梁丽, 等. 基于微钻试验金刚石钻头钻进速度的研究[J]. 地质科技情报, 2015, 34(2): 221-224. https://www.cnki.com.cn/Article/CJFDTOTAL-DZKQ201502033.htm

    Mei D, Zeng S Y, Liang L, et al. Research on impregnated diamond bit drilling speed based on micro drilling experiment[J]. Geological Science and Technology Information, 2015, 34(2): 221-224(in Chinese with English abstract). https://www.cnki.com.cn/Article/CJFDTOTAL-DZKQ201502033.htm
    [26]
    田敏, 蔡记华, 谷天本, 等. 高寒地区岩石可钻性分析及金刚石钻头选型[J]. 地质科技情报, 2014, 33(2): 171-174. https://www.cnki.com.cn/Article/CJFDTOTAL-DZKQ201402029.htm

    Tian M, Cai J H, Gu T B, et al. Rock drillability analysis and diamond bit model selection in Alpine regions[J]. Geological Science and Technology Information, 2014, 33(2): 171-174(in Chinese with English abstract). https://www.cnki.com.cn/Article/CJFDTOTAL-DZKQ201402029.htm
    [27]
    石祥超, 陶祖文, 孟英峰, 等. 牙轮钻头牙齿破岩机理研究进展[J]. 地质科技情报, 2014, 33(4): 225-230. https://www.cnki.com.cn/Article/CJFDTOTAL-DZKQ201404035.htm

    Shi X C, Tao Z W, Meng Y F, et al. The mechanism of rock breakage during bit-tooth penetration: A review[J]. Geological Science and Technology Information, 2014, 33(4): 225-230(in Chinese with English abstract). https://www.cnki.com.cn/Article/CJFDTOTAL-DZKQ201404035.htm
    [28]
    中石化胜利石油工程有限公司钻井工艺研究院. 石油天然气钻井工程岩石可钻性测定与分级: SY/T 5426-2016[S]. 国家能源局: 2016.

    Drilling Technology Research Institute of Shengli Petroleum Engineering Corporation Limited, SINOPEC. Drilling engineering for the petroleum and natural gas-rock drillability measurement and its grading: SY/T 5426-2016[S]. National Energy Administration: 2016(in Chinese with English abstract).
    [29]
    Kumari W G P, Ranjith P G, Perera M S A, et al. Temperature-dependent mechanical behaviour of Australian Strathbogie granite with different cooling treatments[J]. Engineering Geology, 2017, 229: 31-44.
    [30]
    Griffiths L, Heap M J, Baud P, et al. Quantification of microcrack characteristics and implications for stiffness and strength of granite[J]. International Journal of Rock Mechanics and Mining Sciences, 2017, 100: 138-150.
    [31]
    梁铭, 张绍和, 舒彪. 不同冷却方式对高温花岗岩巴西劈裂特性的影响[J]. 水资源与水工程学报, 2018, 29(2): 186-193. https://www.cnki.com.cn/Article/CJFDTOTAL-XBSZ201802031.htm

    Liang M, Zhang S H, Shu B. Effect of different cooling ways on Brazilian tension characteristics of heat-treated granite[J]. Journal of Water Resources and Water Engineering, 2018, 29(2): 186-193(in Chinese with English abstract). https://www.cnki.com.cn/Article/CJFDTOTAL-XBSZ201802031.htm
    [32]
    李利峰, 邓慧琳, 张晓虎, 等. 加载速率对实时高温花岗岩三轴力学特性影响的实验研究[J]. 科学技术与工程, 2020, 20(16): 6397-6403. https://www.cnki.com.cn/Article/CJFDTOTAL-KXJS202016013.htm

    Li L F, Deng H L, Zhang X H, et al. Experimental study on the effect of loading rate on triaxial mechanical properties of real-time high temperature granite[J]. Science Technology and Engineering, 2020, 20(16): 6397-6403(in Chinese with English abstract). https://www.cnki.com.cn/Article/CJFDTOTAL-KXJS202016013.htm
    [33]
    闵明, 张强, 蒋斌松, 等. 实时高温下北山花岗岩劈裂试验及声发射特性[J]. 长江科学院院报, 2020, 37(3): 108-113. https://www.cnki.com.cn/Article/CJFDTOTAL-CJKB202003019.htm

    Min M, Zhang Q, Jiang B S, et al. Splitting tests and acoustic emission characteristics of Beishan granite under real-time high temperature[J]. Journal of Yangtze River Scientific Research Institute, 2020, 37(3): 108-113(in Chinese with English abstract). https://www.cnki.com.cn/Article/CJFDTOTAL-CJKB202003019.htm
    [34]
    闫炎, 管志川, 玄令超, 等. 复合冲击条件下PDC钻头破岩效率试验研究[J]. 石油钻探技术, 2017, 45(6): 24-30. https://www.cnki.com.cn/Article/CJFDTOTAL-SYZT201706005.htm

    Yan Y, Guan Z C, Xuan L C, et al. Experimental study on rock breaking efficiency with a PDC bit under conditions of composite percussion[J]. Petroleum Drilling Techniques, 2017, 45(6): 24-30(in Chinese with English abstract). https://www.cnki.com.cn/Article/CJFDTOTAL-SYZT201706005.htm
    [35]
    潘德元, 何计彬. 钻井岩屑分形分析的现场应用研究[J]. 探矿工程: 岩土钻掘工程, 2016, 43(11): 11-14. https://www.cnki.com.cn/Article/CJFDTOTAL-TKGC201611003.htm

    Pan D Y, He J B. Research on the field application of analysis on cutting particle size[J]. Exploration Engineering: Rock & Soil Drilling and Tunneling, 2016, 43(11): 11-14(in Chinese with English abstract). https://www.cnki.com.cn/Article/CJFDTOTAL-TKGC201611003.htm
    [36]
    高元宏, 梁俭, 刘鹏, 等. 青海东昆仑重点成矿带岩石钻进特性及金刚石钻头使用效果分析[J]. 地质科技情报, 2017, 36(5): 228-231. https://www.cnki.com.cn/Article/CJFDTOTAL-DZKQ201705031.htm

    Gao Y H, Liang J, Liu P, et al. Characteristics of rock drilling and the effect of diamond bits used in the key metallogenic belt in East Kunlun, Qinghai[J]. Geological Science and Technology Information, 2017, 36(5): 228-231(in Chinese with English abstract). https://www.cnki.com.cn/Article/CJFDTOTAL-DZKQ201705031.htm
    [37]
    Shi X C, Gao L Y, Wu J, et al. Effects of cyclic heating and water cooling on the physical characteristics of granite[J]. Energies, 2020, 13(9): 1-18.
    [38]
    Glover P W J, Band P, Darot M, et al. α/β phase transition in quartz monitored using acoustic emissions[J]. Geophysical Journal International, 1995, 120(3): 775-782.
    • Relative Articles
    • Supplements(0)
    • Cited By
  • 加载中

Catalog

    通讯作者: 陈斌, bchen63@163.com
    • 1. 

      沈阳化工大学材料科学与工程学院 沈阳 110142

    1. 本站搜索
    2. 百度学术搜索
    3. 万方数据库搜索
    4. CNKI搜索
    Get Citation
    PDF
    XML

    Article Metrics

    Article Views(316) PDF Downloads(44) Cited by()
    Proportional views
    Related

    Copyright © 2010Editorial Department of Bulletin of Geological Science and Technology    

    Supported by: Beijing Renhe Information Technology Co., Ltd.    

    /

    DownLoad:  Full-Size Img  PowerPoint
    Return
    Return